deoxy does it rust remover


 

Material Safety Data Sheet

E-Z Safe Solutions DEOXY-DOES-IT

Product Hazard: Health: 0 Fire: 0 Toxicity: 0 Reactivity: 0 Special: 0

Hazard Rating: 4 = Deadly 3 = Extreme 2 = Hazardous 1= Slight Hazard 0 = Normal

1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING 09/06/90

Product Name: DEOXY-DOES-IT

Manufacturer/Supplier: NCM SUPPLY CO.  L.L.C. (PROD.ID 3GXN8)

3945 Church St.
Willoughby, OH 44094

Emergency Telephone Number: (440) 602-7200 or
800-233-6573 (in the U.S.)

2. INGREDIENTS

Contains no hazardous components under current OSHA definitions.

*These chemicals are subject to reporting requirements off section 313 of the Emergency Planning and Right-To-Know Act of 1986 and of

40 CFR 372.

3. HAZARDS IDENTIFICATION

Carcinogen: NA NTP: NA IARC Monograph: NA OSHA: NA

Primary Routes of Entry: Eye - Yes Ingestion - Yes Inhalation - NA Skin - Yes

Effects of overexposure: Eye - none Ingestion - nausea Inhalation - none Skin - none

Most Important Hazards: None

Specific Hazards: None

4. FIRST AID MEASURES

General Advice: Product exhibits no adverse effects.

Inhalation: Non-reactive - No First Aid needed.

Skin Contact: Slight skin irritant after prolonged contact, PDII = 0.9. Not dermally toxic, LD50> 2,000 mg/kg.

Eye Contact: Slight eye irritant, MMTS = 0.0.. Rinse thoroughly with plenty of water.

Ingestion: Product is non-toxic. Deoxy-does-it  tested to be non-toxic when orally dosed at a concentration of 5 g/kg in rats. If necessary, give victim two glasses of water and

INDUCE VOMITING by using ipecac syrup or placing two fingers at the back of the throat. Get immediate attention. Do not give anything by mouth to an unconscious person.

5. FIRE-FIGHTING MEASURES

Suitable Extinguishing Media: Dry chemical, CO2

Special Fire Fighting Procedures: Wear SCBA & all protective equipment

Specific Hazards: None

Flash Point: None

6. ACCIDENTAL RELEASE MEASURES

Personal Precautions: None needed. Caution floor may be slippery.

Environmental Precautions: None needed; non-toxic, non-hazardous in neat form.

Methods for Cleaning Up: Filter and reuse or dispose directly by flushing area with water into sewer.

SAFETY DATA SHEET Page: 2 of 2

7. HANDLING AND STORAGE

Corrosivity: slight corrosive.

Technical Measures/Precautions: Normal ventilation is adequate.

Safe Handling Advice: Avoid contact with eyes.  Use of Gloves recommended. Technical Measures/Storage Conditions: Low temperature can cause handling problems. Viscosity of material will increase. Incompatible Products: No special restrictions on storage with other products.

Packaging Material: No restrictions.

8. EXPOSURE CONTROLS/PERSONAL PROTECTION

Engineering Measures: General room ventilation is satisfactory.

Control Parameters: None needed.

Personal Protection Equipment

Respiratory: None needed.

Eye: Not an eye irritant, MMTS = 0.0. Safety glasses may be used.

Hand: Slight skin irritant after prolonged exposure, PDII = 0.9. Not dermally toxic, LD50> 2,000 mg/kg. Gloves can help retain natural moisture.

Hygiene Measures: Employ good hygiene measures.

9. PHYSICAL AND CHEMICAL PROPERTIES

Form: Water viscous liquid Color: Light amber to yellow

Odor: Slight/Pleasant odor pH: 5.7 - 6.3

Boiling Point/Range: >200°F Melting Point/Range: Not Applicable

Freezing Point: 32°F/0°C Viscosity @ 25°C: same as water

Flash Point: None Explosive Properties: None

% Volatile by weight: >85% Water Solubility: Complete

Vapor Pressure: NA Vapor Density: NA air =1

Surface Tension: Not determined Specific Gravity: 1.036 - 1.042

Evaporation Rate: >1 ether=1 (same as water) Volatile Organic Compounds: None known

10. STABILITY AND REACTIVITY

Stability: Normally Stable

Conditions to Avoid: High temperatures

Materials to Avoid: Avoid contact with strong oxidizing agents or other reactive materials.

Hazardous Decomposition Products: Oxides of carbon

Hazardous Polymerization: Will not occur

11. TOXICOLOGICAL INFORMATION

Acute Toxicity: Non-toxic. Deoxy-does-it tested to be non-toxic when orally dosed at a concentration of 5 g/kg in rats. None of the test animals showed any adverse affects to the test article. At the study's completion, all rats were necropsied and each animal appeared normal for gross pathology.

Local Effects: None.

Specific Effects: None.

12. ECOLOGICAL INFORMATION

Non-toxic, non-hazardous, safe for the environment.

13. DISPOSAL CONSIDERATIONS

Waste from Residues/Unused Products: Non-hazardous. Sewerable in neat form. Product container is recyclable.

Contaminated Packaging: If recycling is not practicable, dispose of in compliance with the Environmental Protection (Duty of Care)

Regulations 1991 if contaminated with hazardous materials. May be disposed of in neat form.

14. TRANSPORTATION INFORMATION

Not classified as dangerous or hazardous in the meaning of transport regulations.

15. REGULATORY INFORMATION

Product complies with all known regulatory considerations and is unregulated and not listed as a Hazmat by any agency.

16. OTHER INFORMATION

Recommended Use: Rust Remover

The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification.

The information relates only to the specific material designated and is not valid for such material used in combination with any other materials or in any process, unless specified in the text.

You're viewing the Material Safety Data Sheet webpage



Rust Remover

Deoxy Does It
Website Design, SEO and Developement by Website Weaver